Mitsubishi Galant

1990 — 2001 of release

Repair and car operation


Mitsubishi Galant
+ Identification numbers of the car
+ Governing bodies
+ Settings and routine maintenance
+ Engine
+ cooling and heating Systems
+ Power supply system and release
+ engine Electric equipment
- Control systems of the engine
   Specifications
   System of operated ventilation of a case (PCV) - the general information, check of a condition and replacement of components
   System of catching of fuel evaporations (EVAP) - the general information, check of a condition and replacement of components
   System of a retsirkulyatsiya of the fulfilled gases (EGR) - the general information, check of a condition and replacement of components
   System of onboard diagnostics (OBD) - a principle of functioning and codes of malfunctions
   Replacement of the module of management (ECM/PCM)
   Information sensors and actuation mechanisms - the general information, check of serviceability of functioning, removal and installation
   The catalytic converter - the general information, check of a condition and replacement
+ Manual transmission
+ Coupling and transmission line
+ Brake system
+ Suspension bracket and steering
+ Body
+ Onboard electric equipment


Specifications

Oxygen sensors
Resistance at temperature 20°С, Ohm
6
Range of fluctuations of alarm tension (between HO2S and SIG RTN plugs), In
0.01 ÷ 1.0
Servomotor of system of stabilization of turns of idling (IAC)
Resistance, Ohm
Between plugs 2-1 and 2-3
28 ÷ 33
Between plugs 1-4 and 5-6
28 ÷ 33
The sensor of temperature of cooling liquid of the engine (ECT)
Resistance, lump
At temperature 0°С
5.1 ÷ 6.5
At temperature 20°С
2.1 ÷ 2.7
At temperature 40°С
0.9 ÷ 1.3
At temperature 80°С
0.26 ÷ 0.36
The sensor of temperature of soaked-up air (IAT)
Resistance (between plugs 6 and 8), a lump
At temperature 0°С
5.3 ÷ 6.7
At temperature 20°С
2.3 ÷ 3.0
At temperature 80°С
0.30 ÷ 0.42
Sensor of measurement of an air stream (MAF)
Tension In
Between BATT and GND plugs (at the included ignition and not started engine)
10.5
Between SIG and GND plugs (at the working engine)
4.5
Between SIG RTN and GND plugs (at the working engine)
0.34 ÷ 1.96
The sensor of absolute pressure in the inlet pipeline (MAP)
Tension In
Between SIG and GND plugs (at the included ignition and not started engine)
4.8
Between SIG RTN and GND plugs (at the working engine)
At the released pedal of gas
0.8 ÷ 2.4
At the squeezed-out pedal of gas
2.4
Sensor of provision of a butterfly valve (TPS)
Tension, In
At single turns of the engine
0.2 ÷ 1.4
At completely open butterfly valve
4.8
Sensor of temperature of EGR (the Californian models)
Resistance, lump
At temperature 50°С
60 ÷ 83
At temperature 100°С
11 ÷ 14
Electromagnetic valve of a purge of a coal adsorber of EVAP
Resistance at temperature 20°С, Ohm
Models till 1994 вып.
36 ÷ 44
Models since 1994 вып.
25 ÷ 44
Efforts of a tightening of carving connections of Nanometer
Oxygen sensor
37 ÷ 45
ECT 30 sensor
EGR valve
Models of 1.5 l, 1.6 l and 1.8 l
10 ÷ 15
Models of 2.0 l
15 ÷ 22
Models of 2.4 l and 3.5 l
11
Sensor of temperature of EGR (the Californian models)
12
Thermovacuum EGR valve
20 ÷ 40